High RPM Stalling Problem - Kawasaki Teryx Forums: Kawasaki UTV Teryx Forum
Kawasaki Teryx Performance Discussions Kawasaki Teryx performance discussions.
Engine mods, CDI boxes, exhausts, etc.

User Tag List

 
LinkBack Thread Tools Display Modes
post #1 of 3 (permalink) Old 11-05-2010, 08:59 AM Thread Starter
Junior Member
 
Join Date: Nov 2010
Posts: 1
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 0 Post(s)
 
High RPM Stalling Problem

Hey everyone.

My name is Aaron Jagger; Iím currently deployed to Afghanistan and attached to a US Army Special Forces team in a very remote location. We have a 2009 Teryx 750 that we use on our patrols through the local area.

The problem I am having is intermittent, but has been occurring more often recently. At full throttle the engine bogs down to a near stall, before increasing RPM's in almost a cyclic pattern: up, down, up, down, up, down ect. If the throttle is slowly increased the engine has no problem keeping up until approximately half throttle, when it bogs down again. This is with the transmission in neutral, so no load on the engine.

If the transmission is in gear it happens just the same, although it seems to happen earlier in the RPM range.

I have done the basic troubleshooting (changed engine oil/filter, pulled and cleaned spark plugs, inspected the throttle bodies for damage, Cleaned the air filter and inspected the air box for damage, and changed out the ECU) and have come up short.

Now I am no expert on the Teryx, in fact prior to a month ago I had never seen one before, so if anyone has seen this problem before, or has any suggestions as to what I should be looking for, I would greatly appreciate it.

Thanks.
Jagger is offline  
Sponsored Links
Advertisement
 
post #2 of 3 (permalink) Old 11-05-2010, 01:55 PM
TeryxHQ.com Staff Member
 
DougS's Avatar
 
Join Date: Apr 2008
Location: Alberta, Canada
Posts: 2,107
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 1 Post(s)
 
I'd start with new spark plugs, check coils and spark plug wires/connections.
I assume you changed the fuel filter and made sure the throttle bodies and the bowl are clean. Are they sliding freely?
For some reason I thought the US Army got the carburated version. If it is when it bogs, is it a bit better pulling the choke or not?


Good luck with your issue. Come back safe and thank you for serving.
DougS is offline  
post #3 of 3 (permalink) Old 11-06-2010, 07:45 AM
Senior Member
 
Join Date: May 2008
Posts: 3,999
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 0 Post(s)
 
First off thanks for serving our country!!


Let's verify it is EFI or a carb model



Hunterworks is offline  
Sponsored Links
Advertisement
 
Reply

Bookmarks

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Kawasaki Teryx Forums: Kawasaki UTV Teryx Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
teyx stalling or dying hllywood Kawasaki Teryx General Discussions 10 12-29-2010 01:37 PM
High Water Crossings dieselpowered Kawasaki Teryx General Discussions 12 12-18-2010 07:15 AM
Idle is way to high Shane99 Kawasaki Teryx General Discussions 5 06-06-2010 04:57 PM
flying high at dumont!! sconym Kawasaki Teryx Suspension Discussions 4 03-30-2009 04:36 AM
Sup from Az.---stalling issue Az-LeeRoy Member Introductions 1 10-06-2008 07:04 PM

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome
 


1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89